How much is a set of double-bucket quantitative packaging machine for organic and inorganic fertiliz

When choosing a double-bucket quantitative packaging machine for organic/inorganic fertilizers, whether it is in powder or granular form will directly affect the equipment selection and price. The following is a detailed analysis and purchase suggestions for different forms:

I. The Key Impact of Powdered vs. Granular Fertilizers on Equipment

Comparison items | Powdered fertilizer | Granular fertilizer

Poor fluidity, prone to dust and caking | Good, easy to weigh and fill

Equipment requirements | Dust-proof and arch-breaking design is required | Anti-breakage design is required (such as soft landing)

Precision control | Higher (prone to drift) | Relatively easy (stable fluidity)

Typical configuration differences | Installing dust collectors and vibration arch breaking devices | Reducing the discharge height and buffering hoppers

Ii. Reference prices for equipment corresponding to different forms of fertilizers

Special double-bucket packaging machine for powdered fertilizers

Basic model: 56,000-80,000 yuan (Carbon steel material, semi-automatic, including simple dust removal)

High-end model: 80,000-250,000 yuan (Stainless steel contact parts + automatic weighing, sealing, sewing machine, counting, infrared wire cutting, edge folding, etc.)

2. Special double-bucket packaging machine for granular fertilizers

Basic model: 52,000-100,000 yuan (Carbon steel material, gravity self-flow filling)

High-end model: 120,000-180,000 yuan (stainless steel + automatic weighing, sealing, sewing machine, counting, infrared wire cutting, edge folding, etc.)

Note: The double-bucket design is usually 20% to 30% more expensive than the single-bucket design, but its efficiency is increased by more than 50%.

Iii. Recommendations for Cost-effective Purchasing Channels

Zhengzhou area: Zhengzhou Hanke Machinery (rich experience, stable equipment performance, low failure rate, and good after-sales service.)

Iv. Guide to Avoiding Pitfalls in Double-Bucket Quantitative Packaging Machines for Organic and Inorganic Fertilizers

Beware of the low-price trap:

Powder equipment with a quotation of less than 60,000 yuan may not have dust removal and cause long-term environmental pollution.

For granular equipment with a cost of less than 40,000, a belt scale may be used instead of a gravity scale, with an error of more than 1%.

2. Key points of machine inspection:

Powder form: Test 10 bags and weigh them continuously to observe the dust-raising and caking conditions.

Particles: Check the breakage rate (fragile particles with a drop of more than 50cm).

3. Contract Remarks:

Clearly state "suitable material form" to avoid inapplicability to general models.

V. Conclusion and Suggestions

Provide samples to manufacturers for trial operation (supported by most major factories), and the measured data is more important than the parameters. Before deciding to purchase, it is recommended to compare the products and prices of multiple suppliers and choose the equipment that suits your own needs.